Super Weapon Swap System

"Check, we must thoroughly investigate where these stamping parts come from!" director Zhang's face was iron blue. At this time, it was evening and it was time to get off work.

As the equipment is still being debugged and the personnel are also being trained, the factory's production capacity has not come up. This is the stage of small batch trial assembly in the automobile factory. Therefore, there is no need to work in three shifts and have enough time to investigate.

The investigation is also very simple, because it was applied according to the strict quality management system of the North heavy truck factory, so every part has a label.

Soon, the reason was found. The stamping parts of this batch of cars were scrapped!

Yes, although the scrap symbol on the surface of stamping parts was erased, the label on the car and the signature of the quality inspector were clearly marked with the words of scrap. Who knows, it was ignored by the workers in this workshop!

Director Wang's face was also ugly. He thought that no one would know if these parts were mixed in. Who would have thought that someone would be investigated in less than five minutes.

There is nothing wrong with the quality inspector. He scrapped the parts according to the scrapping standard. However, this batch of parts flowed into the next workshop process of the factory. Then, whose responsibility is it?

"Xiao Liu, what's the matter?" director Zhang asked Xiao Liu, who was responsible for delivering waste. He pushed out and dumped the waste onto the waste pile. Who knows, now it flows back!

Of course, the person responsible for the investigation should be found out from Xiao Liu.

Xiao Liu hesitated and dared not speak. Looking at him, he knew that there must be something wrong with him.

"We didn't strictly follow our production procedures, resulting in strict production accidents. Five BIW were scrapped and the factory lost tens of thousands of yuan. According to our requirements, it should be dismissed!" director Zhang said severely.

In this era, entering the factory means holding an iron rice bowl. I don't know how many people envy it. But now, director Zhang's word is about to dismiss Xiao Liu, which means that Xiao Liu's future is gone.

Director Wang finally couldn't help it. He beat the dog to see the owner. Isn't it obvious that he can't find happiness for me? Even if you were airborne, so what? You can't make this factory fly like a chicken and make people panic, so it will show that your new official has three fires in office, right?

"Lao Zhang, what's going on? I feel sorry for these parts, so I took them back. Look, haven't I repaired them to the same as the original?" director Wang stood up and said.

So what? What's the big deal? Isn't that what we did before? We've been hammering for so many years. Now, you say it's impossible? You have to use a machine to punch it out. If there is a slight defect, it will be scrapped. How wasteful is it?

"Our country is poor. In the past, everyone was knocking and making do. What's the big deal?" director Wang continued.

"Yes." his words immediately attracted a lot of echoing voices.

After hearing his words, director Zhang couldn't help it anymore: "quality, quality, quality, look at what slogans are hanging in our factory?"

Quality is the life of the factory!

Zero tolerance is required for quality defects!

Change ideas, change work style, pay close attention to management and improve quality!

Almost all slogans carry these two words, that is, quality!

Without quality, it is absolutely impossible!

Director Zhang continued: "you see, although you knocked out the BIW with a hammer, can the hammering accuracy be compared with our stamping accuracy?"

Then he pulled the door back and forth twice and said, "you see, because the accuracy is not enough, the push-pull door is not flexible. There is always a jam. When the car is sold to the user, what should the user say when he finds that the door is difficult to use? He will certainly say that our quality is not good!"

Director Zhang took out the caliper again, watched the door close, stretched in and continued: "The gap between our doors should not exceed 2mm, but now? Under your beating, the gap at the door is 5mm! Most of our users are aimed at the countryside. If the car is not tightly sealed on the dirt roads in the countryside, it will enter the soil and seriously affect our reputation. If a village buys only one car, the reputation will spread Now that we are in the market, we must not let our unqualified defective products leave the factory! "

Director Zhang's words, the people present still can't agree. What if the seal is not tight? Which car is tightly sealed now? Look at the old liberation, isn't it full of dust? Even when it was built in the past, there were only half of the doors. They can't understand. It takes a long process to make them understand. When the view of the society comes a few years later, When the quality of vans produced by Haihe automobile factory was even higher than that of Santana, when the supply of vans was in short supply and the annual output of 300000 vehicles was not enough, they realized that quality is the first vitality.

Now, we can only force them to accept this idea and give them a deep impression!

When director Zhang just wanted to take the next step, he RI Bala came.

Due to the new factory here, he ribala is not at ease. He has been in charge of the factory these days. Now, when he heard that there was a problem in production, he came immediately.

When he ribala came over, he saw that director Zhang was explaining the quality problems to the people present, and most of the people actually didn't think so.

"Take these defective products to the gate of the factory," he ribala said.

At this time, he RI Bala didn't say anything else, and the people present didn't know what his intention was. However, with the quarrel here, more and more people were watching.

When these defective products were pulled to the gate of the factory, it was already a sea of people, three floors inside and three floors outside.

He ribala, with a big hammer in his hand, walked slowly to the side of the defective products. When he saw his appearance, everyone present knew what was going to happen.

"I know that many of our teachers feel that some scrapped things can be used if they make do, but now I want to solemnly tell you that as long as they are scrapped, they are scrapped. There is no way to make do except returning to the furnace! If you make do and fool users now, you are fooling the factory and your own future! Such a thing is absolutely not allowed Appear again in the factory! "

Then he picked up the sledgehammer. In the public's attention, he ribala's sledgehammer smashed at the scrapped white body, and also smashed in the hearts of these people.